Sciact
  • EN
  • RU

Propylene/ethylene Copolymerization over Titanium–Magnesium Catalysts with Different Morphology and Different Composition of Internal Donors Научная публикация

Журнал Iranian Polymer Journal
ISSN: 1026-1265 , E-ISSN: 1735-5265
Вых. Данные Год: 2025, DOI: 10.1007/s13726-025-01551-6
Ключевые слова Titanium–magnesium (Ziegler–Natta) catalysts; Propylene/ethylene copolymerization; Copolymerization constants; Catalyst particle morphology; Internal stereoregulating donor
Авторы Garkul Arina S. 1 , Barabanov Artem A. 1 , Zakharov Vladimir A. 1 , Matsko Mikhail A. 1
Организации
1 Boreskov Institute of Catalysis SB RAS, pr. Akademika Lavrentieva 5, Novosibirsk, Russia 630090

Информация о финансировании (1)

1 Министерство науки и высшего образования Российской Федерации (с 15 мая 2018) FWUR-2024-0037

Реферат: The data on the constants of copolymerization of propylene with ethylene over highly active titanium–magnesium catalysts under conditions when produced a statistical copolymer containing 3–5 mol% of ethylene was obtained. Catalysts with different particle size and porous structure, as well as catalysts containing different internal stereoregulating donors phthalate, 1,3-diether and succinate were studied. The constant of copolymerization of propylene with ethylene (r2 value) was found to increase as the average size of catalyst particles increases from 12 to 25 µm. A further increase of particle size to 51 µm had virtually no effect on the copolymerization ability of catalyst. At the same time, the pores volume for a catalyst with a particle size of 12–14 microns did not affect the value of r2. It was revealed that catalyst TMC-S containing an internal donor succinate had a highest copolymerization ability (a lower r2 value compared to catalysts TMC-P and TMC-D containing stereoregulating donors phthalate and 1,3-diether, respectively). The data on the constants of copolymerization ethylene with propylene (the r1 value) over titanium–magnesium catalysts TMC-D, TMC-P, and TMC-S had been obtained under conditions when a statistical copolymer containing 6 mol% propylene was produced. It was found that under these conditions all the catalysts had close copolymerization abilities: copolymerization constant r1 is independent of the composition of an internal donor. It was found, the propylene/ethylene copolymers produced over phthalate and succinate catalysts have close wide MWD (in contrast to homopolymer), while the copolymer obtained over diether catalyst has a narrower MWD.
Библиографическая ссылка: Garkul A.S. , Barabanov A.A. , Zakharov V.A. , Matsko M.A.
Propylene/ethylene Copolymerization over Titanium–Magnesium Catalysts with Different Morphology and Different Composition of Internal Donors
Iranian Polymer Journal. 2025. DOI: 10.1007/s13726-025-01551-6 Scopus
Даты:
Принята к публикации: 1 июл. 202 г.
Поступила в редакцию: 14 янв. 2025 г.
Опубликована online: 5 сент. 2025 г.
Идентификаторы БД:
Scopus: 2-s2.0-105015393058
Цитирование в БД: Пока нет цитирований
Альметрики: